SUPPLEMENTARY INFORMATION:

I. Overview

YTC has determined that certain Yokohama brand RY023 replacement commercial tires do not fully comply with paragraph S6.5(d) and (j) of Federal Motor Vehicle Safety Standard (FMVSS) No. 119, New Pneumatic Tires for Motor Vehicles with a GVWR of more than 4,536 kilograms (10,000 lbs) and Motorcycles (49 CFR 571.119). YTC filed a noncompliance report dated July 12, 2018, pursuant to 49 CFR part 573, Defects and Noncompliance Responsibility and Reports. YTC ( printed page 29281) subsequently petitioned NHTSA on July 31, 2018, and submitted a supplemental petition on February 6, 2019, for an exemption from the notification and remedy requirements of 49 U.S.C. Chapter 301 on the basis that this noncompliance is inconsequential as it relates to motor vehicle safety, pursuant to 49 U.S.C. 30118(d) and 30120(h) and 49 CFR part 556, Exemption for Inconsequential Defect or Noncompliance.

II. Tires Involved

Approximately 4,704 Yokohama RY023 size 11R22.5 16(LR H) 146/143L commercial tires manufactured between February 2, 2018, and May 17, 2018, are potentially involved.

III. Noncompliance

YTC explains that the noncompliance was due to a mold error in which one sidewall, the serial sidewall, of subject tires incorrectly state the ply rating, load range and load capacity as required by paragraph S6.5(d) and (j) of FMVSS No. 119.

Specifically, the tires were marked:

14 PR LOAD RANGE G

MAX. LOAD SINGLE 2800 kg (6175 lbs) at 720 kPa (105 psi) COLD

MAX. LOAD DUAL 2650 kg (5840 lbs) at 720 kPa (105 psi) COLD

When they should have been marked:

16 PR LOAD RANGE H

MAX. LOAD SINGLE 3000 kg (6610 lbs) at 830 kPa (120 psi) COLD

MAX. LOAD DUAL 2725 kg (6005 lbs) at 830 kPa (120 psi) COLD

IV. Rule Requirements

Paragraph S6.5(d) and (j) of FMVSS No. 119, includes the requirements relevant to this petition:

• Except as specified in paragraph S6.5, each tire shall be marked on each sidewall with the information specified in paragraphs (a) through (j) of paragraph S6.5.
• The maximum load rating and corresponding inflation pressure of the tire, shown as follows:

(Mark on tires rated for single and dual load): Max load single __ kg (__ lb) at __ kPa (__ psi) cold. Max load dual __ kg (__ lb) at __ kPa (__ psi) cold.

(Mark on tires rated for only for single load): Max load single __ kg (__ lb) at __ kPa (__ psi) cold.

• Markings must contain the letter designating the tire load range.

V. Summary of Petition

YTC described the subject noncompliance and stated its belief that the noncompliance is inconsequential as it relates to motor vehicle safety.

In support of its petition, YTC submitted the following arguments:

1. This Petition concerns Yokohama 11R22.5 16PR RY023 commercial truck and bus replacement tires whose branding information incorrectly states the ply rating, load range and load capacity on one side (serial side) only, while the branding information on the other side (opposite serial side) is correct for the subject tires. Because of this mold branding error, these tires are not in compliance with the tire labeling requirement found in 49 CFR 571.119 S6.5(d) and (j), even though all of these tires were manufactured with the correct ply rating and load range.

2. YTC implemented verification countermeasures to prevent any recurrence of any incorrect tire markings. Further investigation determined that the suspect period ended when the incorrect mold had been removed from production on May 17, 2018, in the 19th production week of 2018. The 764 tires in containment will be repaired before they are sold.

3. Significantly, these tires were manufactured as designed and meet or exceed all applicable Federal motor vehicle safety performance standards. While the sidewall markings are correct on the opposite serial side, the sidewall markings on the serial side understate the construction and capacity of the subject tires. The misbranding of these tires is not a safety concern and also has no impact on the retreading, repairing and recycling industries. The affected tire mold has already been corrected and all future production will have the correct material shown on the sidewall.

4. NHTSA has studied the impact of tire labeling information on safety in the context of its rulemaking efforts under the Transportation Recall Enhancement, Accountability and Documentation (TREAD) Act. YTC stated that NHTSA's analysis concluded that tire construction information on a tire's sidewall is not relied upon by dealers and consumers in the selling or purchasing of tires and has an inconsequential impact on motor vehicle safety. In addition, YTC cited the following petitions that the agency has previously granted for similar noncompliances: See Sumitomo Rubber Industries, Grant of Petition for Decision of Inconsequential Noncompliance, 83 FR 13002 (March 26, 2018) and Goodyear Tire & Rubber Co., Grant of Petition for Decision for Inconsequential Noncompliance, 82 FR 18210 (April 17, 2017).

YTC concluded by expressing the belief that the subject noncompliance is inconsequential as it relates to motor vehicle safety, and that its petition to be exempted from providing notification of the noncompliance, as required by 49 U.S.C. 30118, and a remedy for the noncompliance, as required by 49 U.S.C. 30120, should be granted.

YTC's complete petition and all supporting documents are available by logging onto the Federal Docket Management System (FDMS) website at: https://www.regulations.gov and by following the online search instructions to locate the docket number as listed in the title of this notice.

NHTSA notes that the statutory provisions (49 U.S.C. 30118(d) and 30120(h)) that permit manufacturers to file petitions for a determination of inconsequentiality allow NHTSA to exempt manufacturers only from the duties found in sections 30118 and 30120, respectively, to notify owners, purchasers, and dealers of a defect or noncompliance and to remedy the defect or noncompliance. Therefore, any decision on this petition only applies to the subject tires that YTC no longer controlled at the time it determined that the noncompliance existed. However, any decision on this petition does not relieve tire distributors and dealers of the prohibitions on the sale, offer for sale, or introduction or delivery for introduction into interstate commerce of the noncompliant tires under their control after YTC notified them that the subject noncompliance existed.

Authority: 49 U.S.C. 30118, 30120: delegations of authority at 49 CFR 1.95 and 501.8.

84 FR 29280